All Issue

2018 Vol.50, Issue 5 Preview Page
Development of Packaging Material by Surface coating Treatment of Eco-friendly Composite Resins

친환경 복합레진 표면처리에 의한 종이 포장재 개발

So-Ra Back
,
Won-Jae Youe
,
Tae-Ju Lee1
,
Hyoung-Jin Kim2†
백소라
,
유원재
,
이태주 1
,
김형진 2†
Division of Wood Processing, National Institute of Forest Science, 57 Hoegiro, Dongdaemun-gu, Seoul, 02455
1Division of Wood Chemistry, National Institute of Forest Science, 57 Hoegiro, Dongdaemun-gu, Seoul, 02455
2Department of Forest Products and Biotechnology, College of Science and Technology, Kookmin University, Seoul,02707
국립산림과학원 목재가공연구과
1국립산림과학원 목재화학연구과
2국민대학교 과학기술대학 임산생명공학과
†Corresponding author: E-Mail: hyjikim@kookmin.ac.kr
30 October 2018. pp. 55-63
PDF XML Citation
Abstract

In this paper, applicability of biodegradable polymers which could replace the paraffin wax was studied in order to provide the water resistance and biodegradability to corrugated boxes. Optimum blending ratio based on paraffin wax was found by measuring sizing degree and paper strength. As a result, when PVA (polyvinyl alcohol) and SC (sodium caseinate) were blended 20% with paraffin wax, the highest water resistance was observed. In case of paper coated with PVA and paraffin wax, the compression strength (ring crush test) of the coated paper was 1200 N/m higher than that of base paper. Stability of the coated paper was also analyzed under cold temperature (-25℃). All strength of properties of the coated papers decreased for prolonged exposure time at –25℃. Nevertheless strength of the coated paper was still higher than that of base paper after exposure under cold condition. Consequently, it could be considered that eco-friendly coating resin prepared by blending paraffin wax and PVA would be possible for application to corrugated box to be distributed under cold temperature.

Keywords
Biopolymer
paraffin wax
blending ratio
freeze chain
packaging paper
References

Literature Cited

1
Joongang Daily, , Available form: https://news.joins.com/article/21982917 (2017-September-29)

Joongang Daily, September 29 (2017). Available form: https://news.joins.com/article/21982917.

2
D. Van Hung, Y. Nakano, F. Tanaka, D. Hamanaka and T. Uchino, Composites Science and Technology, Preserving the strength of corrugated cardboard under high humidity condition using nano-sized mists, 70(14); 2123-2127 (2010)

Van Hung, D., Nakano, Y., Tanaka, F., Hamanaka, D., and Uchino, T., Preserving the strength of corrugated cardboard under high humidity condition using nano-sized mists, Composites Science and Technology 70(14): 2123-2127 (2010).

3
B. Sadlowsky, V. Kostner, M. Mazur, S. K. Thun and P. Borocz, Acta Technica Jaurinensis, Determination of safety factors for mango fruit paperboard transport crates under refrigerated conditions, 11(1); 34-43 (2018)

Sadlowsky, B., Kostner, V., Mazur, M., Thun, S. K., and Borocz, P., Determination of safety factors for mango fruit paperboard transport crates under refrigerated conditions, Acta Technica Jaurinensis 11(1):34-43 (2018).

10.14513/actatechjaur.v11.n1.448
4
J. Y. Lee, C. H. Kim, E. H. Kim, T. U. Park and J. S. Choi, Journal of Korea TAPPI, Study on the manufacture of ethylene gas absorbing corrugated board, 48(2); 20-27 (2016)

Lee, J. Y., Kim, C. H., Kim, E. H., Park, T. U., and Choi, J. S., Study on the manufacture of ethylene gas absorbing corrugated board, Journal of Korea TAPPI 48(2):20-27 (2016).

10.7584/ktappi.2016.48.2.020
5
H. W. Park, Y. S. Ha, S. D. Lee, J. H. Kong and S. I. Kim, Korean Journal of Food Science and Technology, Changes in compression strength of corrugated paperboard box in several conditions, 21(2); 258-261 (1989)

Park, H. W., Ha, Y. S., Lee, S. D., Kong, J. H., and Kim, S. I., Changes in compression strength of corrugated paperboard box in several conditions, Korean Journal of Food Science and Technology 21(2):258-261 (1989).

6
M. H. Lee, J. Y. Jo and J. S. Shin, Journal of Korea TAPPI, Changes of the physical properties of corrugated fiberboard boxes for fruit and vegetable packaging by preservation temperature and relative humidity, 34(1); 46-53 (2002)

Lee, M. H., Jo, J. Y., and Shin, J. S., Changes of the physical properties of corrugated fiberboard boxes for fruit and vegetable packaging by preservation temperature and relative humidity, Journal of Korea TAPPI 34(1):46-53 (2002).

7
H. J. Youn, H. L. Lee, S. M. Chin and I. S. Choi, Journal of Korea TAPPI, Physical properties of linerboard and corrugated fiberboard at the cyclic condition of low humidity, 39(2); 38-44 (2007)

Youn, H. J., Lee, H. L., Chin, S. M., and Choi, I. S., Physical properties of linerboard and corrugated fiberboard at the cyclic condition of low humidity, Journal of Korea TAPPI 39(2):38-44 (2007).

8
J. Y. Jo, C. K. Min and J. S. Shin, Journal of Korea TAPPI, Manufacture of water-resistant corrugated board boxes for agricultural products in the cold chain system, 44(2); 29-34 (2012)

Jo, J. Y., Min, C. K., and Shin, J. S., Manufacture of water-resistant corrugated board boxes for agricultural products in the cold chain system, Journal of Korea TAPPI 44(2):29-34 (2012).

10.7584/ktappi.2012.44.2.029
9
J. Y. Jo, C. K. Min and J. S. Shin, Journal of Korea TAPPI, Manufacture of water-resistant corrugated board boxes for agricultural products in the cold chain system (I), 35(2); 26-32 (2003)

Jo, J. Y., Min, C. K., and Shin, J. S., Manufacture of water-resistant corrugated board boxes for agricultural products in the cold chain system (I), Journal of Korea TAPPI 35(2):26-32 (2003).

10
J. Y. Jo, C. K. Min and J. S. Shin, Journal of Korea TAPPI, Manufacture of water-resistant corrugated board boxes for agricultural products in the cold chain system (II) - application methods of chemicals for improving water and moisture resistance of corrugated boards, 36(2); 60-69 (2004)

Jo, J. Y., Min, C. K., and Shin, J. S., Manufacture of water-resistant corrugated board boxes for agricultural products in the cold chain system (II) - application methods of chemicals for improving water and moisture resistance of corrugated boards, Journal of Korea TAPPI 36(2):60-69 (2004).

11
S. Sönmez and Ö. Özden, Barrier properties of paper and cardboard, In Academic Researches in Architecture, Engineering Planning and Design; 171-183 (2018)

Sönmez, S. and Özden, Ö., Barrier properties of paper and cardboard, In Academic Researches in Architecture, Engineering Planning and Design, pp. 171-183 (2018).

12
R. E. Popil and M. Schaepe, Tappi J, Comparative evaluation of the potential for wax-alternative packaging coatings, 4(8); 25 (2005)

Popil, R. E., and Schaepe, M., Comparative evaluation of the potential for wax-alternative packaging coatings, Tappi J. 4(8):25 (2005).

13
T. Fei, J. A. Walker, K. L. Vickerman, L. M. Stanley, D. Jarboe and T. Wang, Journal of Industrial and Engineering Chemistry, Synthesis and characterization of soybean oil-based waxes and their application as paraffin substitute for corrugated coating, 58; 113-122 (2018)

Fei, T., Walker, J. A., Vickerman, K. L., Stanley, L. M., Jarboe, D., and Wang, T., Synthesis and characterization of soybean oil-based waxes and their application as paraffin substitute for corrugated coating, Journal of Industrial and Engineering Chemistry 58:113-122 (2018).

10.1016/j.jiec.2017.09.015
14
K. J. Kim, M. H. Lee and T. J. Eom, Journal of Korea TAPPI, Preparation of emulsion from biodegradable polymer (II) - Characteristics of paper treated as PLA and PBS emulsion, 45(2); 13-20 (2013)

Kim, K. J., Lee, M. H., and Eom, T. J., Preparation of emulsion from biodegradable polymer (II) - Characteristics of paper treated as PLA and PBS emulsion, Journal of Korea TAPPI 45(2):13-20 (2013).

10.7584/ktappi.2013.45.2.013
15
M. Nowacka, K. Rybak, A. Wiktor, A. Mika, P. Boruszewski, J. Woch, K. Przybysz and D. Witrowa-Rajchert, Food Control, The quality and safety of food contact materials - paper and cardboard coated with paraffin emulsion, 93; 183-190 (2018)

Nowacka, M., Rybak, K., Wiktor, A., Mika, A., Boruszewski, P., Woch, J., Przybysz, K., and Witrowa-Rajchert, D., The quality and safety of food contact materials - paper and cardboard coated with paraffin emulsion, Food Control 93:183-190 (2018).

10.1016/j.foodcont.2018.06.011
16
J. W. Rhim, J. H. Lee and S. I. Hong, LWT-Food Science and Technology, Water resistance and mechanical properties of biopolymer (alginate and soy protein) coated paperboards, 39(7); 806-813 (2006)

Rhim, J. W., Lee, J. H., and Hong, S. I., Water resistance and mechanical properties of biopolymer (alginate and soy protein) coated paperboards, LWT-Food Science and Technology 39(7):806-813 (2006).

10.1016/j.lwt.2005.05.008
17
J. W. Rhim, J. H. Lee and S. I. Hong, Packaging Technology and Science: An International Journal, Increase in water resistance of paperboard by coating with poly (lactide), 20(6); 393-402 (2007)

Rhim, J. W., Lee, J. H., and Hong, S. I., Increase in water resistance of paperboard by coating with poly (lactide), Packaging Technology and Science: An International Journal 20(6):393-402 (2007).

10.1002/pts.767
18
V. K. Rastogi and P. Samyn, Coatings, Bio-based coatings for paper applications, 5(4); 887-930 (2015)

Rastogi, V. K., and Samyn, P., Bio-based coatings for paper applications, Coatings 5(4):887-930 (2015).

10.3390/coatings5040887
19
T. Y. Kim, Y. J. Joung, D. K. Kim, Y. D. Heo and Y. J. Sung, Journal of Korea TAPPI, Effects of relative humidity on the physical properties of PVA impregnated paper, 42(3); 37-42 (2010)

Kim, T. Y., Joung, Y. J., Kim, D. K., Heo, Y. D., and Sung, Y. J., Effects of relative humidity on the physical properties of PVA impregnated paper, Journal of Korea TAPPI 42(3): 37-42 (2010).

20
J. Moon, M. H. Kim, Y. T. Lee, H. H. Lee and Y. H. Rho, Journal of the Korea Academia-Industrial Cooperation Society, Study on the biodegradable ability of biodegradable plastics PLA (polylactic acid) by composting, 17(4); 596-605 (2016)

Moon, J., Kim, M. H., Lee, Y. T., Lee, H. H., and Rho, Y. H., Study on the biodegradable ability of biodegradable plastics PLA (polylactic acid) by composting, Journal of the Korea Academia-Industrial Cooperation Society, 17(4):596-605 (2016).

10.5762/kais.2016.17.4.596
21
K. M. Jeong, J. H. Lee, T. J. Lee, J. Y. Ryu and Kum. Nam Lee, Journal of Korea TAPPI, The evaluation of the fruit bag property (I) - property of the oil coated paper (pear bag paper) -, 49(5); 5-11 (2017)

Jeong, K. M., Lee, J. H., Lee, T. J., Ryu, J. Y., and Lee, Kum. Nam., The evaluation of the fruit bag property (I) - property of the oil coated paper (pear bag paper) -, Journal of Korea TAPPI 49(5):5-11 (2017).

10.7584/jktappi.2017.10.49.5.5
Information
  • Publisher :Korea Technical Association of The Pulp and Paper Industry
  • Publisher(Ko) :한국펄프종이공학회
  • Journal Title :Journal of Korea TAPPI
  • Journal Title(Ko) :펄프종이기술
  • Volume : 50
  • No :5
  • Pages :55-63
  • Received Date : 2018-09-18
  • Revised Date : 2018-10-08
  • Accepted Date : 2018-10-10
  • DOI :https://doi.org/10.7584/JKTAPPI.2018.10.50.5.55
Journal Informaiton Journal of Korea TAPPI Journal of Korea TAPPI
Online Submission
  • scopus
  • NRF
  • KOFST
  • crossref crossmark
  • crossref cited-by
  • crosscheck
  • orcid
Journal Informaiton Journal Informaiton - close