Development of Manufacturing Technology of Fish Block Liner for Frozen Fish Packaging (II) : Study on Bubble Coating Technology for the Manufacturing of Domestic Fish Block Liner

Ji Young Lee; Jong Suk Lee; Jae Sung Choi; Hae Min Jo; Kyung Min Kim; Su Ho Kim; Chul Hwan Kim

doi:10.7584/JKTAPPI.2019.06.51.3.32

All Issue

2019 Vol.51, Issue 3 Preview Page Next Page

Development of Manufacturing Technology of Fish Block Liner for Frozen Fish Packaging (II) : Study on Bubble Coating Technology for the Manufacturing of Domestic Fish Block Liner 수산물 냉동포장용 블록라이너의 제조 기술 개발(II) : 국산 블록라이너 제조를 위한 버블 코팅에 대한 연구

30 June 2019. pp. 32-38

PDF XML

Abstract

In a previous study, we found that the deep pores in the coating layers of imported fish block liner have higher Cobb size degrees and lower Gurley air permeability than the domestic prototype block liners and coated linerboards. However, it is impossible to obtain such pores when using the conventional wax coating process; thus, a new coating method is required.

In this study, we evaluated a new technique to achieve porous coating layers in coated linerboard. Various mixtures of paraffin wax, low density polyethylene (LDPE), and ethylene vinyl acetate (EVA) were prepared. Then, water spraying was used during conventional coating process to form the pores. The surface of samples coated with and without water spray were analyzed using scanning electron microscopy (SEM). The Cobb size degree and Gurley porosity of coated linerboard were measured in the SEM images to assess the existence of deep pores in the wax coating layer.

The 80:15:5 mixture of paraffin wax, LDPE, and EVA reduced the Gurley porosity of coated linerboard. Water spraying was an effective method to obtain porous wax coating layers; better results were observed when using cold water. In addition, a relatively low mixing temperature of the paraffin wax, LDPE, and EVA led to an adequate formation of pores in the wax coating layer. A linerboard with properties similar to those of imported fish block liner was successfully obtained; this material could be used for manufacturing domestic fish block liner.

Keywords

Fish block liner

Cobb size degree

Gurley air permeability

burst strength

pore

References

Literature Cited

T. Fei, J. A. Walker, K. L. Vickerman, L. M. Stanley, D. Jarboe and T. Wang, Journal of Industrial and Engineering Chemistry, Synthesis and characterization of soybean oil-based waxes and their application as paraffin substitute for corrugated coating, 58; 113-122 (2018)

Fei, T., Walker, J. A., Vickerman, K. L., Stanley, L. M., Jarboe, D., and Wang, T., Synthesis and characterization of soybean oil-based waxes and their application as paraffin substitute for corrugated coating, Journal of Industrial and Engineering Chemistry 58:113-122 (2018).

10.1016/j.jiec.2017.09.015

M. Nowacka, K. Rybak, A. Wiktor, A. Mika, P. Boruszewski, J. Woch, K. Przybysz and D. Witrowa-Rajchert, Food Control, The quality and safety of food contact materials – paper and cardboard coated with paraffin emulsion, 93; 183-190 (2018)

Nowacka, M., Rybak, K., Wiktor, A., Mika, A., Boruszewski, P., Woch, J., Przybysz, K., and Witrowa-Rajchert, D., The quality and safety of food contact materials – paper and cardboard coated with paraffin emulsion, Food Control 93:183-190 (2018).

10.1016/j.foodcont.2018.06.011

S. R. Back, W. J. Youe, T. J. Lee and H. J. Kim, Journal of Korea TAPPI, Development of packaging material by surface coating treatment of eco-friendly composite resins, 50(5); 55-63 (2018)

Back, S. R., Youe, W. J., Lee, T. J., and Kim, H. J., Development of packaging material by surface coating treatment of eco-friendly composite resins Journal of Korea TAPPI 50(5):55-63 (2018).

10.7584/jktappi.2018.10.50.5.55

J. L. Xu and D. W. Sun, International Journal of Refrigeration, Identification of freezer burn on frozen salmon surface using hyperspectral imaging and computer vision combined with machine learning algorithm, 74; 151-164 (2017)

Xu, J. L., Sun, D. W., Identification of freezer burn on frozen salmon surface using hyperspectral imaging and computer vision combined with machine learning algorithm, International Journal of Refrigeration 74:151-164 (2017).

10.1016/j.ijrefrig.2016.10.014

A. C. Laura, O. S. Viviana and H. M. Rodolfo, International Journal of Heat and Mass Transfer, Food freezing with simultaneous surface dehydration: Approximate prediction of freezing time, 48(6); 1205-1213 (2005)

Laura, A. C., Viviana, O. S., and Rodolfo, H. M., Food freezing with simultaneous surface dehydration: Approximate prediction of freezing time, International Journal of Heat and Mass Transfer 48(6):1205-1213 (2005).

R. B. Laurence and M. V. Alexander, Frozen fish package (1976)

Laurence, R. B., and Alexander, M. V., Frozen fish package, US patent 3967024 (1976).

B. S. Roar, Block carton with finish coating (2005)

Roar, B. S., Block carton with finish coating, US patent 0252953 (2005).

B. S. Roar, Block carton (2009)

Roar, B. S., Block carton, US patent 0114709 (2009).

J. Y. Lee, J. S. Lee, J. S. Choi, T. U. Park, H. M. Jo, K. M. Kim and C. H. Kim, Journal of Korea TAPPI, Development of manufacturing technology of fish block liner for frozen fish packaging (I) - Analysis of coating layers and physical properties of fish block liner -, 50(5); 100-106 (2018)

Lee, J. Y., Lee, J. S., Choi, J. S., Park, T. U., Jo, H. M., Kim, K. M., and Kim, C. H., Development of manufacturing technology of fish block liner for frozen fish packaging (I) - Analysis of coating layers and physical properties of fish block liner - Journal of Korea TAPPI 50(5):100-106 (2018).

10.7584/jktappi.2018.10.50.5.100

Information

Publisher :Korea Technical Association of The Pulp and Paper Industry
Publisher(Ko) :한국펄프종이공학회
Journal Title :Journal of Korea TAPPI
Journal Title(Ko) :펄프종이기술
Volume : 51
No :3
Pages :32-38
Received Date : 2019-05-10
Revised Date : 2019-06-07
Accepted Date : 2019-06-10
DOI :https://doi.org/10.7584/JKTAPPI.2019.06.51.3.32

Journal of Korea TAPPI ISSN:0253-3200(Print) 펄프종이기술

All Issue

Literature Cited